Bluetooth mic got me baffled

dstill · Post by **dstill** » Mon May 13, 2013 12:20 pm

I've searched for this and cannot find an answer to my problem. Installed a genuine VW bluetooth kit in my mates Scirocco but cant get the mic to pick up any sound. You can hear the caller fine through the speakers but cant hear the driver talking.

There is a lot of stuff on here about the dB level but i've checked this and used different levels both + and - settings. I've checked the coding and it seems fine and also masde sure the mic wires were installed in the connector block at the correct polarity but still can't fathom this out!

Pablosammy · Post by **Pablosammy** » Mon May 13, 2013 12:35 pm

Sorry if this is stating the obvious, but did you remove the black foam spacer piece from the microphone housing before clipping the mic into place?

Can't rule out a dodgy microphone either - are there any relevant error codes?

maq · Post by **maq** » Mon May 13, 2013 5:11 pm

Might sound a silly question, but which end of the quadlock harness did you install the mic wires, and have you wired it direct to the Bluetooth module or to the RNS/RCD with pass through?

dstill · Post by **dstill** » Mon May 13, 2013 9:19 pm

Pablosammy wrote:Sorry if this is stating the obvious, but did you remove the black foam spacer piece from the microphone housing before clipping the mic into place?

Can't rule out a dodgy microphone either - are there any relevant error codes?

No worries mate, appreciate the suggestions.

I did however take the foam out, i may use the mic in my Scirocco and put it on my mates as i know thats ok. I can't recall any error codes but probably need to do another autoscan.

dstill · Post by **dstill** » Mon May 13, 2013 9:23 pm

maq wrote:Might sound a silly question, but which end of the quadlock harness did you install the mic wires, and have you wired it direct to the Bluetooth module or to the RNS/RCD with pass through?

No mate, not silly, just helpful and i appreciate your help. The harness came already made up so i just plugged it in. The mic go's straight to the bluetooth module which i know is correct as i previosuly had to re-route mine to get voice control activated.

maq · Post by **maq** » Mon May 13, 2013 9:46 pm

If you can give me some more info about the install, it might help us work out the issue...

Is it for an RNS 510?
If so, does the car have voice control?
If also the case, I assume the mic was pre-installed?

Most current harness/looms come with a passthrough loop so the mic goes into the RNS, then back out to the bluetooth unit through the loom itself.

If you have an RNS 510 and voice control with the mic pre-installed, then the correct set up is usually for the mic to be wired into the RNS end of the quadlock in pins 1 & 7 on the bottom left whilst looking at the quad lock face on (opposite side to the fuse).

The RNS then has an output that goes from it, to the bluetooth unit, so the mic effectively passes through and thats often pre-wired in the harness, but I can't remember which pins off the top of my head.

Some harnesses I've seen even have a set of connectors to allow you to either connect the mic either to the quadlock, or to an additional connection that is direct to the BT unit (but still part of the harness). In the former case and the mic is going into the quadlock, the other connectors have to be bridged to form the output to the BT module.

Difficult to explain without pictures, unfortunately my loom is now well hidden behind the dash

happy to help though if you can provide more info or close up pics of the loom.

maq · Post by **maq** » Mon May 13, 2013 9:49 pm

RNS quadlock mic outputs appear to be pins 4 & 9 according to http://www.my-gti.com/529/volkswagen-rn ... ssignments" onclick="window.open(this.href);return false;

Worth checking what you have hooked up to those, unless you are indeed running your mic direct into a different connector as part of the harness direct to the BT module.

mwilkins · Post by **mwilkins** » Thu May 16, 2013 9:08 am

Hi dstill,

I am looking to fit the factory bluetooth to my car this weekend, did you follow a guide online? I think I understand most of it but cannot workout where the microphone should go. I was looking to install the module behind the head-unit rather than under the seat.

Thanks.

maq · Post by **maq** » Thu May 16, 2013 9:30 am

mwilkins,

Do you mean in terms of running the mic up into the OEM position or A-Pillar, or are you talking about the wiring/pins into the quadlock?

Plenty of guides online around bluetooth installation, I think my-gti.com has one if I recall correctly

Thanks
Maq

dstill · Post by **dstill** » Mon May 20, 2013 11:55 am

The car has an RCD 510 so teh mic goes directly to the bluetooth module, i've checked the connections between the bluetooth module and the mic and they seem fine. I tested the mic on my own car and it works fine so it cant be that at fault.

I did an autoscan and it is showing two faults in theTelephone controller, mic open circuit and antenna open circuit, what would you guys suggest doing to resolve this, results of the autoscan are below.

Sunday,19,May,2013,17:32:01:04747
VCDS Version: Release 11.11.5 (x64)
Data version: 20121222

--------------------------------------------------------------------------------
--------------------------------------------------------------------------------

Chassis Type: 1K0
Scan: 01 03 08 09 14 15 16 17 19 25 2E 42 44 46 52 56 77

VIN: **************************

01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: OK 0000
14-Susp. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
56-Radio -- Status: OK 0000
77-Telephone -- Status: Malfunction 0010

-------------------------------------------------------------------------------
Address 01: Engine (CBB) Labels: 03L-906-022-CBA.clb
Part No SW: 03L 906 022 LC HW: 03L 906 022 G
Component: R4 2,0L EDC 0000SG 6655
Revision: 13H03--- Serial number:
Coding: 0001072
Shop #: WSC 00020 790 00000
VCID: 71EFE8D568BB9190DE2

No fault code found.
Readiness: 0 0 0 0 1

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels: 1K0-907-379-60EC1F.clb
Part No SW: 1K0 907 379 AH HW: 1K0 907 379 AH
Component: ESP MK60EC1 H30 0107
Revision: 00H30001
Coding: 763B60F5492500036E0C06E592210082300000
Shop #: WSC 00020 790 00000
VCID: 78F9D5F1CBC1C0D819C

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels: 5K0-907-044.clb
Part No SW: 5K0 907 044 BS HW: 5K0 907 044 BS
Component: Climatronic H15 0709
Revision: 00003001
Coding: 0000000002
Shop #: WSC 00020 999 00000
ASAM Dataset: EV_Climatronic A01006
ROD: EV_Climatronic_VW36.rod
VCID: 7DF7C4E5ECE3E5F04AA

1 Fault Found:
9481200 - Coolant Pressure
B10AB F0 [009] - Too Low
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 95
Mileage: 41223 km
Date: 2036.14.06
Time: 17:22:51

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels: 1K0-937-08x-09.clb
Part No SW: 5K0 937 086 C HW: 5K0 937 086 C
Component: BCM PQ35 M 011 0028
Revision: BC011001
Coding: 48100A389827E100408800843400012643713B88537D81605C8000000000
Shop #: WSC 00020 790 12345
VCID: 346121C19729E4B8F54

Subsystem 1 - Part No: 1K8 955 119 E Labels: 1KX-955-119.CLB
Component: Wischer 22011 22 0614
Coding: 009795

Subsystem 2 - Part No: 1K0 955 559 AH Labels: 1K0-955-559-AG.CLB
Component: RLS 260210 05 54 0403
Coding: 0330ED

Subsystem 3 - Part No: 1K8 951 171
Component: DWA-Sensor 00 001 0104
Coding: 000000

Subsystem 4 - Part No: 1K8 951 605
Component: LIN BACKUP HO H09 9002
Coding: 000000

No fault code found.

-------------------------------------------------------------------------------
Address 14: Susp. Elect. (J250) Labels: None
Part No SW: 3C0 907 376 A HW: 3C0 907 376
Component: DAEMPFUNGS-SG H07 0070
Revision: 00000000 Serial number: 02031007250002
Coding: 000180
Shop #: WSC 00020 790 00000
VCID: 275BC68D56FF9F20406

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags Labels: 1K0-909-605.lbl
Part No SW: 1K0 909 605 AE HW: 1K0 909 605 AE
Component: 0H AIRBAG VW8 020 2300
Revision: 05020000 Serial number: 003D1D025G9J
Coding: 0012360
Shop #: WSC 00020 790 00000
VCID: 6FEBEEAD7E8F8760C86

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels: 5K0-953-569.clb
Part No SW: 5K0 953 521 T HW: 5K0 953 569 D
Component: LENKS.MODUL 009 0122
Revision: FF010035 Serial number: 20100225200559
Coding: 1082040000
Shop #: WSC 00020 999 00000
ASAM Dataset: EV_SMLSNGVOLWS A01002
ROD: EV_SMLSNGVOLWS_VW36.rod
VCID: 3D7704E5AC6325F00AA

Multifunction steering wheel control module:
Subsystem 1 - Part No SW: 5K0 959 542 HW: 5K0 959 542 Labels: 3C8-959-537.CLB
Component: E221__MFL-TAS H05 0010
Coding: 820000

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels: 5K0-920-xxx-17.clb
Part No SW: 1K8 920 971 C HW: 1K8 920 971 C
Component: KOMBI H05 0305
Serial number: 00000000000000
Coding: 470B00
Shop #: WSC 00020 999 00000
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04052
ROD: EV_Kombi_UDS_VDD_RM09_VW36.rod
VCID: 336322DD9A27E380ECE

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 1K0-907-530-V4.clb
Part No SW: 1K0 907 530 AD HW: 1K0 907 951
Component: J533 Gateway H16 0233
Revision: H16 Serial number: 4520K102260559
Coding: E9881F06000612004001
Shop #: WSC 00020 790 12345
VCID: 69DF80B5406B6950962

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels: 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5K0 953 234
Component: IMMO H05 0305
Serial number:
Coding: 000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03005
ROD: EV_Immo_UDS_VDD_RM09_VW36.rod
VCID: EADD7FB90D6DE2481F8

No fault code found.

-------------------------------------------------------------------------------
Address 2E: Media Player 3 (J650) Labels: 5N0-035-342.lbl
Part No SW: 5N0 035 342 B HW: 5N0 035 342 B
Component: SG EXT.PLAYER H13 0090
Revision: A1001003 Serial number: 7667843369
Coding: 010000
Shop #: WSC 00000 000 00000
VCID: 2645CB8951F586287B0

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: 1K0-959-701-MAX3.lbl
Part No SW: 1Q0 959 701 H HW: 1Q0 959 701 H
Component: Tuer-SG 009 2124
Coding: 0016949
Shop #: WSC 00020 790 00000
VCID: 397F10F5704B19D0262

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1Kx-909-14x-44.clb
Part No: 1K0 909 144 J
Component: EPS_ZFLS Kl. 177 3001
Revision: 00H17000
Shop #: WSC 00020 790 00000
VCID: 316F28D5A83BD1909E2

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: 1K0-959-702-MAX3.lbl
Part No SW: 1Q0 959 702 H HW: 1Q0 959 702 H
Component: Tuer-SG 009 2124
Coding: 0016948
Shop #: WSC 00020 790 00000
VCID: 3A7D0FF9754D12C82F8

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio (J0503) Labels: 5M0-035-1xx-56.clb
Part No SW: 3C8 035 195 HW: 3C8 035 195
Component: Radio RCD510 040 0166
Revision: 00000001 Serial number: VWZ1Z3K6364684
Coding: 0100040004
Shop #: WSC 00020 790 00000
VCID: E5C70C85EC73CD3032A

No fault code found.

-------------------------------------------------------------------------------
Address 77: Telephone (J412) Labels: 7P6-035-730.clb
Part No SW: 7P6 035 730 L HW: 7P6 035 730 L
Component: TELEFON H15 3200
Revision: 1B001001 Serial number: 00007663534789
Coding: 0200090100000110
Shop #: WSC 12345 123 12345
ASAM Dataset: EV_UHVNA 002720
ROD: EV_UHVNA_VW36.rod
VCID: 3B730AFDB2772BC034E

2 Faults Found:
9455635 - Telephone Microphone
B1048 13 [009] - Open Circuit
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 4
Fault Frequency: 1
Reset counter: 95
Mileage: 41223 km
Date: 2036.14.06
Time: 17:24:55

9458453 - Cellular Antenna
B1053 15 [009] - Open or Short to Plus
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 4
Fault Frequency: 1
Reset counter: 95
Mileage: 41223 km
Date: 2036.14.06
Time: 17:24:55

End ---------------------------------------------------------------------

maq · Post by **maq** » Mon May 20, 2013 12:43 pm

Your coding looks a little strange. Try the following and see if your errors improve. I don't expect this will sort the mic not working though

0200000000010110

Try the above coding and feedback results. Don't forget to clear errors first

Maq

maq · Post by **maq** » Mon May 20, 2013 12:45 pm

The whole mic open circuit thing is a bit odd though. Can you confirm wiring on your quadlock and what pins you're wired the mic into?

You shouldn't have an antenna on the 7p6 if i recall correctly so coding should fix that.

I'm thinking it might be worth tracing the mic through the harness with a multimeter, as if the mic works it's either the BT unit or the harness. I'd be keen to rule the harness out by showing the right pins in the quadlock connect to the right pins on the BT connector.

dstill · Post by **dstill** » Mon May 20, 2013 2:06 pm

I'll try the coding change you recommmend as a first step.

I was thinking of carrying out a continuity test on the mic cable so will do that also.

Just to clarify the unit is an RCD510 so doesn't have voice control set up hence the mic cable go's striaght to the bluetooth module and not through the quadlock on the back of the RCD. I have checked the mic cable and it connects to the correct pins on the bluetooth module.

maq · Post by **maq** » Mon May 20, 2013 5:24 pm

Understand this is an RCD unit, so your wiring the mic into the loom still but via a connector external to the quadlock? If so, continuity test would definitely be the right approach.

Just confused when you say right into the Bluetooth, assume you mean into the loom which in turn connects to the one socket on the Bluetooth box?

dstill · Post by **dstill** » Tue May 21, 2013 7:15 am

Sorry mate, i dont think i explained it too well. The mic wire is wrapped into the loom but go's directly to the connection at the bluetooth module end, it doesn't go to the quadlock at the back of the RCD.

maq · Post by **maq** » Tue May 21, 2013 10:19 am

Cool. That makes perfect sense

dstill · Post by **dstill** » Thu Jun 13, 2013 7:19 am

maq wrote:The whole mic open circuit thing is a bit odd though. Can you confirm wiring on your quadlock and what pins you're wired the mic into?

You shouldn't have an antenna on the 7p6 if i recall correctly so coding should fix that.

I'm thinking it might be worth tracing the mic through the harness with a multimeter, as if the mic works it's either the BT unit or the harness. I'd be keen to rule the harness out by showing the right pins in the quadlock connect to the right pins on the BT connector.

Hi Maq,

I managed to get time to change the code to the one you suggested and still no luck. I did a continuity test on the harness using a simple circuit tester and it seems fine. I have posted the autoscan I did afterwards below, have you any more ideas mate?

Wednesday,12,June,2013,18:26:07:04747
VCDS Version: Release 11.11.6 (x64)
Data version: 20121223

--------------------------------------------------------------------------------
--------------------------------------------------------------------------------

Chassis Type: 1K0
Scan: 01 03 08 09 14 15 16 17 19 25 2E 42 44 46 52 56 77

VIN: *************

01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
14-Susp. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
56-Radio -- Status: OK 0000
77-Telephone -- Status: Malfunction 1010

-------------------------------------------------------------------------------
Address 01: Engine (CBB) Labels: 03L-906-022-CBA.clb
Part No SW: 03L 906 022 LC HW: 03L 906 022 G
Component: R4 2,0L EDC 0000SG 6655
Revision: 13H03--- Serial number:
Coding: 0001072
Shop #: WSC 00020 790 00000
VCID: 71EFE8D568BB9190DF5

No fault code found.
Readiness: 0 0 0 0 0

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels: 1K0-907-379-60EC1F.clb
Part No SW: 1K0 907 379 AH HW: 1K0 907 379 AH
Component: ESP MK60EC1 H30 0107
Revision: 00H30001
Coding: 763B60F5492500036E0C06E592210082300000
Shop #: WSC 00020 790 00000
VCID: 78F9D5F1CBC1C0D818B

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels: 5K0-907-044.clb
Part No SW: 5K0 907 044 BS HW: 5K0 907 044 BS
Component: Climatronic H15 0709
Revision: 00003001
Coding: 0000000002
Shop #: WSC 00020 999 00000
ASAM Dataset: EV_Climatronic A01006
ROD: EV_Climatronic_VW36.rod
VCID: 7DF7C4E5ECE3E5F04BD

1 Fault Found:
9481200 - Coolant Pressure
B10AB F0 [009] - Too Low
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 95
Mileage: 41223 km
Date: 2036.14.06
Time: 17:22:51

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels: 1K0-937-08x-09.clb
Part No SW: 5K0 937 086 C HW: 5K0 937 086 C
Component: BCM PQ35 M 011 0028
Revision: BC011001
Coding: 48100A389827E100408800843400012643713B88537D81605C8000000000
Shop #: WSC 00020 790 12345
VCID: 346121C19729E4B8F43

Subsystem 1 - Part No: 1K8 955 119 E Labels: 1KX-955-119.CLB
Component: Wischer 22011 22 0614
Coding: 009795

Subsystem 2 - Part No: 1K0 955 559 AH Labels: 1K0-955-559-AG.CLB
Component: RLS 260210 05 54 0403
Coding: 0330ED

Subsystem 3 - Part No: 1K8 951 171
Component: DWA-Sensor 00 001 0104
Coding: 000000

Subsystem 4 - Part No: 1K8 951 605
Component: LIN BACKUP HO H09 9002
Coding: 000000

No fault code found.

-------------------------------------------------------------------------------
Address 14: Susp. Elect. (J250) Labels: None
Part No SW: 3C0 907 376 A HW: 3C0 907 376
Component: DAEMPFUNGS-SG H07 0070
Revision: 00000000 Serial number: 02031007250002
Coding: 000180
Shop #: WSC 00020 790 00000
VCID: 275BC68D56FF9F20411

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags Labels: 1K0-909-605.lbl
Part No SW: 1K0 909 605 AE HW: 1K0 909 605 AE
Component: 0H AIRBAG VW8 020 2300
Revision: 05020000 Serial number: 003D1D025G9J
Coding: 0012360
Shop #: WSC 00020 790 00000
VCID: 6FEBEEAD7E8F8760C91

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels: 5K0-953-569.clb
Part No SW: 5K0 953 521 T HW: 5K0 953 569 D
Component: LENKS.MODUL 009 0122
Revision: FF010035 Serial number: 20100225200559
Coding: 1082040000
Shop #: WSC 00020 999 00000
ASAM Dataset: EV_SMLSNGVOLWS A01002
ROD: EV_SMLSNGVOLWS_VW36.rod
VCID: 3D7704E5AC6325F00BD

Multifunction steering wheel control module:
Subsystem 1 - Part No SW: 5K0 959 542 HW: 5K0 959 542 Labels: 3C8-959-537.CLB
Component: E221__MFL-TAS H05 0010
Coding: 820000

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels: 5K0-920-xxx-17.clb
Part No SW: 1K8 920 971 C HW: 1K8 920 971 C
Component: KOMBI H05 0305
Serial number: 00000000000000
Coding: 470B00
Shop #: WSC 00020 999 00000
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04052
VCID: 336322DD9A27E380ED9

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 1K0-907-530-V4.clb
Part No SW: 1K0 907 530 AD HW: 1K0 907 951
Component: J533 Gateway H16 0233
Revision: H16 Serial number: 4520K102260559
Coding: E9881F06000612004001
Shop #: WSC 00020 790 12345
VCID: 69DF80B5406B6950975

1 Fault Found:
01303 - Telephone Transceiver (R36)
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 3
Reset counter: 150
Mileage: 41223 km
Time Indication: 0

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels: 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5K0 953 234
Component: IMMO H05 0305
Serial number:
Coding: 000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03005
ROD: EV_Immo_UDS_VDD_RM09_VW36.rod
VCID: EADD7FB90D6DE2481EF

No fault code found.

-------------------------------------------------------------------------------
Address 2E: Media Player 3 (J650) Labels: 5N0-035-342.lbl
Part No SW: 5N0 035 342 B HW: 5N0 035 342 B
Component: SG EXT.PLAYER H13 0090
Revision: A1001003 Serial number: 7667843369
Coding: 010000
Shop #: WSC 00000 000 00000
VCID: 2645CB8951F586287A7

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: 1K0-959-701-MAX3.lbl
Part No SW: 1Q0 959 701 H HW: 1Q0 959 701 H
Component: Tuer-SG 009 2124
Coding: 0016949
Shop #: WSC 00020 790 00000
VCID: 397F10F5704B19D0275

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1Kx-909-14x-44.clb
Part No: 1K0 909 144 J
Component: EPS_ZFLS Kl. 177 3001
Revision: 00H17000
Shop #: WSC 00020 790 00000
VCID: 316F28D5A83BD1909F5

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: 1K0-959-702-MAX3.lbl
Part No SW: 1Q0 959 702 H HW: 1Q0 959 702 H
Component: Tuer-SG 009 2124
Coding: 0016948
Shop #: WSC 00020 790 00000
VCID: 3A7D0FF9754D12C82EF

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio (J0503) Labels: 5M0-035-1xx-56.clb
Part No SW: 3C8 035 195 HW: 3C8 035 195
Component: Radio RCD510 040 0166
Revision: 00000001 Serial number: VWZ1Z3K6364684
Coding: 0100040004
Shop #: WSC 00020 790 00000
VCID: E5C70C85EC73CD3033D

No fault code found.

-------------------------------------------------------------------------------
Address 77: Telephone (J412) Labels: 7P6-035-730.clb
Part No SW: 7P6 035 730 L HW: 7P6 035 730 L
Component: TELEFON H15 3200
Revision: 1B001001 Serial number: 00007663534789
Coding: 0200000000010010
Shop #: WSC 12345 123 12345
ASAM Dataset: EV_UHVNA 002720
ROD: EV_UHVNA_VW36.rod
VCID: 3B730AFDB2772BC0359

3 Faults Found:
9455635 - Telephone Microphone
B1048 13 [009] - Open Circuit
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 4
Fault Frequency: 1
Reset counter: 95
Mileage: 41223 km
Date: 2036.14.06
Time: 17:24:55

9457939 - Telephone baseplate
B1051 13 [009] - Open Circuit
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 4
Fault Frequency: 1
Reset counter: 141
Mileage: 42665 km
Date: 2036.14.30
Time: 18:19:21

9458453 - Cellular Antenna
B1053 15 [008] - Open or Short to Plus
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 4
Fault Frequency: 1
Reset counter: 181
Mileage: 41223 km
Date: 2036.14.06
Time: 17:24:55

End ---------------------------------------------------------------------

maq · Post by **maq** » Sun Jun 16, 2013 12:39 pm

I know its a basic/silly question, but you did clear the faults after making the coding changes?

The coding I posted for the 7P6 revision L is bang on as far as I am aware, I've used it myself to remove these errors. I'd double check coding, clear errors and try again.

I'm not sure what to suggest next, although I'd be keen to know what software version is running on the CAN gateway.

I wonder if there is a compatibility issue. I assume you've checked that this unit is compatible with the RCD 510? Will go google now, I wonder what kind of MFD/DIS the car has to?

Maq

dstill · Post by **dstill** » Sun Jun 16, 2013 7:54 pm

To be honest I can’t remember if I cleared the fault codes after putting in the new coding and running an autoscan, I’ll clear them and do an autoscan again to make sure.

If I put the new code in and didn’t clear the faults would that prevent the mic from working?

How do you find out what software the CAN gateway is running? It has the highline white MFD.

By the way Maq, I really appreciate all your help.

dimexi · Post by **dimexi** » Thu Jun 27, 2013 10:31 am

Did this guy have the same problem as you? Check out his post, and his solution.

Scirocco Central